Spray Star 1110 Spray Vehicle

SPRAY STAR 1000 with STAR COMMAND I SYSTEM & 15 Foot (4.5m) Spray Boom

  • Advanced Rate Control Field Computer (TeeJet Radion 8140) with DynaJet Pulse Width Modulation System. Presssure and droplet size control. Wide range of ground speed. Purpose-built spray boom with dual nozzles and dual solenoid valves

SPRAY STAR 1000 with STAR COMMAND I SYSTEM & 18.5 Foot (5.5m) Spray Boom

  • Same extreme application ability as Model 1011A (Above) except 18.5 Foot/5.5m Spray Boom

SPRAY STAR 1000 with STAR COMMAND II SYSTEM & 15 Foot (4.5m) Spray Boom

  • Advanced precision TeeJet Aeros GPS Satellite guided Field Computer. Terra Star Antenna for use with GS, WAAS & Glonass Satellites. Provides Sub-2 in (5 cm) position control and permanently retained mapping. Smithco/TeeJet DynaJet Pulse Width Modulation. Pressure & droplet size control. Wide ground speed range. Purpose built 5 ft (4.5 meter) Spray Boom. Dual Nozzle-Dual Solenoid Valve System.

SPRAY STAR 1000 with STAR COMMAND II SYSTEM & 18.5 Foot (5.5m) Spray Boom

  • Same extreme application accuracy as Model 1015 (Above) except 18.5 ft./5.5mm Spray Boom. Same Annual Subscription Required for GS, GPS & Glonass Satellites. CE & British Sprayer Standards compliance (Optional at extra cost).

STAR COMMAND 3.0 FEATURES

No one matches our 9 years of experience developing the most precise application available for spraying chemicals on turf. With our Partner, TeeJet® Technologies, the Star Command 3.0 System features all of TeeJet’s® previous benefits available on every Star Command sprayer, as well as these exclusive new features:

TURN COMPENSATION corrects flow to keep application rates on target through turns as tight as 20 feet. It lets you avoid straight- line applications on contoured area or rates varying as much as 50% from the inside to the outside of a boom. That doubles the application rate on the inside and cuts the outside rate in half.

TEN INCH NOZZLE SPACING to cut off-target applications in half. This spacing also allows for more efficacy because of increased overlap of the spray patterns.

VIRTUAL, ON-SCREEN NOZZLE CONTROL. TeeJet’s® new job computers operate up to 100 nozzle sections that can be controlled individually. This eliminates the need for extra cabling and job-stopping failure of mechanical switches.

THE DYNAJET SYSTEM is also incorporated into the Aeros 9040 controller, eliminating extra cabling and separate controller.

TERRASTAR-C PRO significantly reduces Convergence Time, to as little as 90 seconds or less.

Spray Star 1110 Specifications

Spray Star 1110 Specifications

IMPERIAL
METRIC
ENGINE
TypeVanguard V-twin air cooled
Displacement38.26 cu. in.
Rated Horsepower23 hp
Air CleanerDouble Action air intake filtration Engine mounted cyclonic filtration system
CoolingAir Cooled
LubricationFull Pressurized
Oil FilterFull Flow, Spin on type
Electrical System24 amp, with 12V 900 CCA battery, fuse protected
Fuel Capacity6 gallons
TRACTION DRIVE
Traction SystemHydraulic power to two rear wheel drive
Hydraulic System5 gallons
Hydraulic CoolingFull flow filter with oil
Tires, Brakes and Steering
TiresFront: 22-10.00×10 Turf, Rear: 24-13.00×12 Multi trac
Service BrakesDynamic braking through hydrostatic transmission
Parking BrakeAuto spring pressure release park brake Manual engagement to both rear wheels
SteeringHydraulic Power Steering with orbitrol motor, 15” steering wheel with tilt adjustment
SPEED
Forward0-8 mph
Reverse0-3 mph
SPRAY TANK
Capacity110 gallons
ConstructionEliptical polyethylene with UV inhibitors. 16” hinged lid with built in locking device and nylon strainer basket
FiltrationDownstream filtration 50 or 80 mesh strainer
AgitationAgitator with 4 venturi volume boosters
PumpRocker switch operated. 10­-70 gpm (36-­225 lpm). 10­-60 psi (0-­7.4 bar). Stainless high volume centrifugal with silicon carbide seals.
SPRAY PERFORMANCE
Application Rates20-220 gallons per acre 0.5-5 gallons per 1000 sq.ft.
Production Rate6.4 acres/hour @ 3.5 mph
WEIGHTS AND DIMENSIONS
WeightDry ­ 1480 lbs | Loaded – 2248 lbs
Length104"
Width70"
Height77"
Wheelbase53"
PRODUCT CONFIGURATION
Leaf spring front suspension
Headlights
“Spray Boss“ mechanical ground speed system & cruise control
Choice of electric or computer spray control system
Certified ROPs with seat belts
SPRAY SYSTEMS
15’ or 18.5’ Super Boom
15’ Super Boom with 9-nozzle, 20”(50cm) spacing or 17-nozzle, 10”(25cm) spacing
1008 TeeJet® Radion 8140 w/ GPS speed sensor
1002 Electric Spray Control System
1010 Manual Spray Control System
1011 Star Command I TeeJet® Radion 8140 and Dynajet System with 15’ boom
1012 Star Command I TeeJet® Radion 8140 and Dynajet System with 18.5’ boom
ACCESSORIES
Water Fill Meter Kit – gallons or liters
Foam Marker – electric operation, manual control
Manual hose Reel – 200’
Electric Hose Reel – 200’
26 Gallon Wash Tank System
Fresh Water Wash Tank
Foam Marker
Chemical Cleanload Safe fill System
Tank Rinse System
3/4” or 5/8” Pressure Hose Kits in 50’, 100’ or 200’ lengths
Pistol Grip JD9 Spray Gun
Drift Reduction Boom Shield
 Print